Muscle Mustangs & Fast FordsProject Vehicles
1999 Ford F150 Lightning Whipple Supercharged - Whip it, Whip It Good - The Fridge Project Truck
When 10.90s aren't enough from your 4,500-pound F-150, add a Whipple-and hold on!
Step By StepView Photo Gallery
While few could argue the Fridge "was" near perfect, there's always room for improvement. That's where the Whipple came in. For the most part, we knew we could increase the power-but could we do so without wrecking the awesome driveability?
In our quest for power, we considered spraying the 5.4-but to what end? We could run low-10s or even 9s with nitrous, but then, no matter how quick we went, people would always assume we were on the gas. While there's nothing wrong with nitrous, we think we can run mid- or low-10s without it. With that, we decided the Whipple was the way to go. We placed our order and received a giant box with a bad, black Whipple Charger inside. We then made our way to JDM Engineering in Freehold, New Jersey, for the install and tune. While the kit included all that's necessary to complete the install, we did not use all the components. Instead, JDM went with its Racer Kit, which uses a different air filter system, different routing on the intercooler hoses, an EGR delete valve, and relocated power steering reservoir.
Installation was straightforward, so we began by disconnecting the negative battery cable and draining the coolant from the intercooler and radiator. Then, the Magnum Powers unit, which served us well, came off and the new blower went into place. Shaun Lacko performed the operation, and by the following afternoon The Fridge was makin' noise.
Jim D'Amore took the reins and strapped our rig to the dyno rollers. That's when the fun began. As we mentioned earlier, the 5.4 produced 579 hp with the Magnum, but with the Whipple, we'd be pumping more boost, which would hopefully translate into more power.
The tank was filled with VP C16, which would allow us to go for broke with boost. But first we used the largest pulley, sized at 3.375 inches. D'Amore began feeding the beast by making easy pulls to be sure the air/fuel ratio was in check, then he cut it loose. He revved the Triton to 5,800, and we saw 18 psi of boost. With that, power peaked at 627 at 5,500 rpm for a gain of 48 hp. Torque was 661 lb-ft at 4,000, up from our old mark of 620 at 4,000. This was our street tune, with timing and boost levels designed for 93 octane.